Conforms to Regulation (EC) No. 1907/2006 (REACH), Annex II, as amended by Commission Regulation (EU)
2015/830 - Europe
Date of issue/ Date of
: 4/5/2018
Date of previous issue
: 9/26/2014
revision
SAFETY DATA SHEET
FINNGARD SILIKAATTIPOHJUSTE (Silicate Primer)
SECTION 1: Identification of the substance/mixture and of the company/
undertaking
1.1 Product identifier
Product name
: FINNGARD SILIKAATTIPOHJUSTE (Silicate Primer)
Product description
: Waterborne silicate paint.
1.2 Relevant identified uses of the substance or mixture and uses advised against
Recommended use: Painting work
1.3 Details of the supplier of the safety data sheet
Manufacturer or Distributor
Tikkurila Oyj
P.O. Box 53
FI-01301 VANTAA
FINLAND
Telephone +358 20 191 2000
e-mail address of person
: Tikkurila Oyj,
responsible for this SDS
Product Safety,
e-mail: xxxxxxxxxxxxx@xxxxxxxxx.xxx
1.4 Emergency telephone number
Telephone number
: 112
(24h)
Supplier or Manufacturer
Telephone number
: Tikkurila Oyj
+358 20 191 2000 (GMT +2) Mon-Fri 8-16
SECTION 2: Hazards identification
2.1 Classification of the substance or mixture
Product definition
: Mixture
Classification according to Regulation (EC) No. 1272/2008 [CLP/GHS]
Eye Dam. 1, H318
The product is classified as hazardous according to Regulation (EC) 1272/2008 as amended.
2.2 Label elements
Hazard pictograms
:
Signal word
: Danger
Hazard statements
: H318 - Causes serious eye damage.
Precautionary statements
General
: P101 - If medical advice is needed, have product container or label at hand.
P102 - Keep out of reach of children.
Prevention
: P261 - Avoid breathing mist/spray.
P271 - Use only outdoors or in a well-ventilated area.
P280 - Wear protective gloves and eye or face protection.
Version
: 1
1/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
Response
: P305 + P351 + P338 - IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing.
P310 - Immediately call a POISON CENTER or physician.
Storage
: Not applicable.
Disposal
: Not applicable.
Hazardous ingredients
: potassium silicate
Supplemental label
: Not applicable.
elements
2.3 Other hazards
Other hazards which do
: None known.
not result in classification
SECTION 3: Composition/information on ingredients
3.2 Mixtures
: Mixture
Classification
Product/ingredient
Identifiers
%
Regulation (EC) No.
Notes
name
1272/2008 [CLP]
potassium silicate
EC: 215-199-1
<10
Skin Irrit. 2, H315
-
CAS: 1312-76-1
Eye Dam. 1, H318
See Section 16 for the full
text of the H statements
declared above.
There are no additional ingredients present which, within the current knowledge of the supplier, are classified and
contribute to the classification of the substance and hence require reporting in this section.
There are no additional ingredients present which, within the current knowledge of the supplier and in the
concentrations applicable, are classified as hazardous to health or the environment, are PBTs or vPvBs or have been
assigned a workplace exposure limit and hence require reporting in this section.
Occupational exposure limits, if available, are listed in Section 8.
Notes, if applicable, refer to Notes given in Annex VI of 1272/2008/EC.
SECTION 4: First aid measures
4.1 Description of first aid measures
General
: In all cases of doubt, or when symptoms persist, seek medical attention. Show this
safety data sheet or label to the doctor if possible.
Eye contact
: Check for and remove any contact lenses. Immediately flush eyes with plenty of
lukewarm water, keeping eyelids open. Continue to rinse for at least 20 minutes.
Get medical attention immediately.
Inhalation
: Remove to fresh air.
Skin contact
: Wash skin thoroughly with soap and water or use recognized skin cleanser. Do
NOT use solvents or thinners.
Ingestion
: If accidentally swallowed rinse the mouth with plenty of water (only if the person is
conscious). If significant amounts have been swallowed or if symptoms persist,
seek medical attention.
4.2 Most important symptoms and effects, both acute and delayed
Causes serious eye damage.
See Section 11 for more detailed information on health effects and symptoms.
4.3 Indication of any immediate medical attention and special treatment needed
None.
Version
: 1
2/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
SECTION 5: Firefighting measures
5.1 Extinguishing media
Suitable extinguishing
: Use an extinguishing agent suitable for the surrounding fire. Recommended:
media
Alcohol resistant foam, CO₂, powders or water spray/mist.
Unsuitable extinguishing
: Do not use a direct water jet that could spread the fire.
media
5.2 Special hazards arising from the substance or mixture
Hazards from the
: This product is not classified as flammable. Fire will produce dense black smoke.
substance or mixture
Exposure to decomposition products may cause a health hazard.
Hazardous combustion
: When exposed to high temperatures, hazardous decomposition products may be
products
produced, such as carbon monoxide and dioxide, smoke, oxides of nitrogen etc.
5.3 Advice for firefighters
Special protective actions
: Use water spray to keep fire-exposed containers cool. Do not release runoff from
for fire-fighters
fire to drains or watercourses.
Special protective
: Fire-fighters should wear appropriate protective equipment and self-contained
equipment for fire-fighters
breathing apparatus (SCBA) with a full face-piece operated in positive pressure
mode.
SECTION 6: Accidental release measures
6.1 Personal precautions,
: Provide adequate ventilation. Avoid breathing vapor or mist. Avoid direct skin
protective equipment and
contact with product. See Section 8 for information on appropriate personal
emergency procedures
protective equipment.
6.2 Environmental
: Do not allow to enter drains, water courses or soil.
precautions
6.3 Methods and materials
: Contain and collect spillage with non-combustible, absorbent material e.g. sand,
for containment and
earth, vermiculite or diatomaceous earth and place in container for disposal
cleaning up
according to local regulations. Preferably clean with water or detergent. Avoid using
solvents.
6.4 Reference to other
: See Section 1 for emergency contact information.
sections
See Section 13 for additional waste treatment information.
SECTION 7: Handling and storage
7.1 Precautions for safe
: Skin contact with the product and exposure to spray mist and vapor should be
handling
avoided. Avoid inhalation of dust from sanding. See Section 8 for information on
appropriate personal protective equipment. Eating, drinking and smoking should be
prohibited in areas where this material is handled and stored. Wash hands before
breaks and immediately after handling the product.
7.2 Conditions for safe
: Store in original container protected from direct sunlight in a dry, cool and well-
storage, including any
ventilated area, away from incompatible materials (see Section 10) and food and
incompatibilities
drink. Keep container tightly closed. Containers that have been opened must be
carefully resealed and kept upright to prevent leakage. Recommended storage
temperature is +5°C ...+25°C. Do not allow to freeze. Store in accordance with local
regulations.
7.3 Specific end use(s)
: None.
Version
: 1
3/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
SECTION 8: Exposure controls/personal protection
8.1 Control parameters
Occupational exposure limits
No exposure limit value known.
Recommended monitoring : If this product contains ingredients with exposure limits, personal, workplace
procedures
atmosphere or biological monitoring may be required to determine the effectiveness
of the ventilation or other control measures and/or the necessity to use respiratory
protective equipment.
DNELs/DMELs
No DNELs/DMELs available.
PNECs
No PNECs available.
8.2 Exposure controls
Appropriate engineering controls
Provide adequate ventilation. Where reasonably practicable, this should be achieved by the use of local exhaust
ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and
solvent vapors below the OEL, suitable respiratory protection must be worn (see Personal protection). Provide a
readily-accessible eyewash facility. Comply with the health and safety at work laws.
Individual protection measures
Eye/face protection
: Wear eye/face protection (EN166).
Hand protection
: Wear protective gloves. Gloves should be replaced regularly and if there is any
sign of damage to the glove material. The instructions and information provided by
the glove manufacturer on use, storage, maintenance and replacement must be
followed.
Recommended glove material (EN374):
> 8 hours (breakthrough time): nitrile rubber
Not recommended: PVA gloves
Skin protection
: Wear appropriate personal protective clothing to prevent skin contact.
Respiratory protection
: If ventilation during spray-application is inadequate, use respirators with
combination filter AP, gas/dust filter (EN405:2001). Wear a respirator with type P2
filter during sanding (EN149:2001). Be sure to use an approved/certified respirator
or equivalent. Check that mask fits tightly and change filter regularly.
SECTION 9: Physical and chemical properties
9.1 Information on basic physical and chemical properties
Appearance
Physical state
: Liquid.
Color
: Coloured
Odor
: Mild.
Odor threshold
: Not relevant for the hazard assessment of the product.
pH
: 11.3 to 11.4
Melting point/freezing point
: Not available.
Initial boiling point and
: Not available.
boiling range
Flash point
: > 100 °C
Evaporation rate
: Not available.
Flammability (solid, gas)
: Not applicable. Product is a liquid.
Upper/lower flammability or
: Not available.
explosive limits
Vapor pressure
: Not available.
Vapor density
: Not available.
Density
: 1.1 g/cm³
Solubility(ies)
: Miscible in water.
Version
: 1
4/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
Partition coefficient: n-octanol/ : Not available.
water
Auto-ignition temperature
: Not available.
Decomposition temperature
: Not relevant for the hazard assessment of the product.
Viscosity
: Not relevant for the hazard assessment of the product.
Explosive properties
: No explosive ingredients present.
Oxidizing properties
: No oxidizing ingredients present.
9.2 Other information
No additional information.
SECTION 10: Stability and reactivity
10.1 Reactivity
: See Section 10.5.
10.2 Chemical stability
: Stable under recommended storage and handling conditions (see Section 7).
10.3 Possibility of
: Under normal conditions of storage and use, hazardous reactions will not occur.
hazardous reactions
10.4 Conditions to avoid
: Avoid extreme heat and freezing.
10.5 Incompatible materials
: Keep away from the following materials to prevent strong exothermic reactions:
oxidizing agents
strong acids
strong alkalis
10.6 Hazardous
: When exposed to high temperatures, hazardous decomposition products may be
decomposition products
produced, such as carbon monoxide and dioxide, smoke, oxides of nitrogen etc.
SECTION 11: Toxicological information
11.1 Information on toxicological effects
There is no testdata available on the product itself.
The product is classified as hazardous according to Regulation (EC) 1272/2008 as amended.
Long term exposure to spray mist may produce respiratory tract irritation. Prolonged or repeated contact can defat
the skin and lead to irritation, cracking and/or dermatitis.
Acute toxicity
Not classified.
Irritation/Corrosion
Causes serious eye damage.
Sensitization
The product is not classified as sensitizing by skin contact, but it contains following preservatives or other biocides
which may produce an allergic reaction:
1,2-benzisothiazol-3(2H)-one (BIT)
2-methyl-2H-isothiazol-3-one (MIT)
Mutagenicity
Not classified.
Carcinogenicity
Not classified.
Reproductive toxicity
Not classified.
Teratogenicity
Not classified.
Specific target organ toxicity (single exposure)
Not classified.
Version
: 1
5/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
Specific target organ toxicity (repeated exposure)
Not classified.
Aspiration hazard
Not classified.
SECTION 12: Ecological information
Ecological testing has not been conducted on this product.
Do not allow to enter drains, water courses or soil.
The product is not classified as environmentally hazardous according to Regulation (EC) 1272/2008.
12.1 Toxicity
: No specific data.
Not available.
12.2 Persistence and
: No specific data.
degradability
12.3 Bioaccumulative
: No specific data.
potential
12.4 Mobility in soil
Soil/water partition
: Not available.
coefficient (KOC)
Mobility
: Not available.
12.5 Results of PBT and vPvB assessment
PBT
: Not applicable.
vPvB
: Not applicable.
12.6 Other adverse effects
: Not available.
SECTION 13: Disposal considerations
13.1 Waste treatment methods
Product
Methods of disposal
: Remove as much product as possible from the tools before cleaning. Liquid residue
and cleaning liquids are hazardous waste and must not be emptied into drains or
sewage system, but handled in accordance with national regulations. Product
residues should be left at special companies which have permission for gathering
this kind of wastes.
European waste catalogue (EWC)
Waste code
Waste designation
08 01 11*
waste paint and varnish containing organic solvents or other hazardous substances
08 01 12
waste paint and varnish other than those mentioned in 08 01 11
If this product is mixed with other wastes, the original waste product code may no longer apply and the appropriate
code should be assigned. For further information, contact your local waste authority.
Packaging
Methods of disposal
: Empty packaging should be recycled or disposed of in accordance with national
regulations.
Special precautions
: No additional information.
Version
: 1
6/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
SECTION 14: Transport information
This product is not regulated for carriage according to ADR/RID, IMDG, IATA.
ADR/RID
IMDG
IATA
14.1 UN number
Not regulated.
Not regulated.
Not regulated.
14.2 UN proper
-
-
-
shipping name
14.3 Transport
-
-
-
hazard class(es)
14.4 Packing
-
-
-
group
14.5
No.
No.
No.
Environmental
hazards
Additional
-
-
-
information
14.6 Special precautions for : Transport within user’s premises: always transport in closed containers that are
user
upright and secure. Ensure that persons transporting the product know what to do in
the event of an accident or spillage.
14.7 Transport in bulk
: Not available.
according to Annex II of
MARPOL and the IBC Code
SECTION 15: Regulatory information
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
EU Regulation (EC) No. 1907/2006 (REACH)
Other EU regulations
Europe inventory
: Not determined.
VOC Directive
: This product is in scope of Directive 2004/42/CE.
15.2 Chemical Safety
: This product contains substances for which Chemical Safety Assessments are still
Assessment
required.
SECTION 16: Other information
Indicates information that has changed from previously issued version.
Abbreviations and
: ATE = Acute Toxicity Estimate
acronyms
CLP = Classification, Labelling and Packaging Regulation [Regulation (EC) No.
1272/2008]
DMEL = Derived Minimal Effect Level
DNEL = Derived No Effect Level
EUH statement = CLP-specific Hazard statement
PBT = Persistent, Bioaccumulative and Toxic
PNEC = Predicted No Effect Concentration
RRN = REACH Registration Number
vPvB = Very Persistent and Very Bioaccumulative
Procedure used to derive the classification according to Regulation (EC) No. 1272/2008 [CLP/GHS]
Classification
Justification
Eye Dam. 1, H318
Calculation method
Version
: 1
7/8
Date of issue/Date of revision
05.04.2018 Date of previous issue
26.09.2014.
FINNGARD SILIKAATTIPOHJUSTE
(Silicate Primer)
Full text of abbreviated H
: H315
Causes skin irritation.
statements
H318
Causes serious eye damage.
Full text of classifications
: Eye Dam. 1, H318
SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 1
[CLP/GHS]
Skin Irrit. 2, H315
SKIN CORROSION/IRRITATION - Category 2
Date of issue/ Date of
: 4/5/2018
revision
Date of previous issue
: 9/26/2014
Version
: 1
Notice to reader
This Safety Data Sheet is prepared in accordance with Annex II (EU) No 830/2015 to Regulation (EC) No
1907/2006 (REACH). The information contained in this Safety Data Sheet is based on the present state of
knowledge and current EU and national legislation. It provides guidance on health, safety and environmental
aspects of the product and should not be construed as any guarantee of technical performance or suitability
for particular applications.
Version
: 1
8/8